Product ID:AGERITE STALITE S, P02909
MSDS Date:08/08/1994
FSC:6810
NIIN:00N091209
Status Code:A
MSDS Number: CJHXN

Emergency Phone: 203-853-1400

Info Phone: 203-853-1400

Cage: 1N612

Telephone: 203-853-1400

Cage: 1N612

MIXTURE OF OCTYLATED DIPHENYLAMINES

CAS: 68411-46-1

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:LD50 (ORAL RAT): 7,580 MG/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:FOR PRODUCT: NONE EXPECTED. FOR
DIPHENYLAMINES: IN GENERAL, MAY BE IRRITATING TO THE MUCOUS
MEMBRANES. HEATING MAY GENERATE VAPORS WHICH CAN IRRITATE EYES AND
THE RESPIRATORY PASSAGES. DUST MAY BE IRR ITATING TO THE UPPER
RESPIRATORY TRACT. MAY CAUSE IRRITATION TO THE EYES, SKIN, AND
UPPER RESPIRATORY SYSTEM.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:UNKNOWN.

First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. CONSULT A
PHYSICIAN. SKIN: WASH WITH SOAP AND WATER. LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE. INHALATION: EXPOSURE TO FRESH AIR. KEEP WARM
AND QUIET. GIVE ARTIFICIAL RESPIRATION. CONSULT A PHYSICIAN.
INGESTION: INDUCE VOMITING BY STICKING FINGER DOWN THROAT OR BY
GIVING SYRUP OF IPECAC. CONSULT A PHYSICIAN.

Flash Point Method:COC
Flash Point:=212.8C, 415.F
Extinguishing Media:FOAM, DRY CHEMICAL, WATER. CARBON DIOXIDE MAY BE
INEFFECTIVE ON LARGE FIRES DUE TO LACK OF COOLING CAPACITY WHICH
MAY RESULT IN REIGNITION.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . IN ENCLOSED OR POORLY VENTILATED AREAS, WEAR NIOSH
APPROVED SCBA DURING CLEANUP IMMEDIATELY AFTER A FIRE AND DURING
FIREFIGHTING.
Unusual Fire/Explosion Hazard:DUST SUSPENDED IN AIR IN CRITICAL
PROPORTIONS & IN PRESENCE OF IGNIT SOURCE PRESENTS EXPLO HAZ. MIN
EXPLO CONC: 0.025 OZ/FT3. MIN IGNIT ENERGY (DUST CLOUD): 0.2 JOULES
@ 0.25 OZ/FT3. MAX RATE OF PRESS RISE: 11,300 PSI/SEC @ 0.1
OZ/FT3. MAX PRESS OF EXPLO: 65 PSIG @ 2.0 OZ/FT3. EXPLO SEVERITY:
3.43 (SEV).

Spill Release Procedures:VACUUM OR SWEEP INTO A CLOSED CONTAINER FOR
DISPOSAL. AVOID DUST GENERATION. DO NOT FLUSH CHEMICAL INTO PUBLIC
SEWER OR WATER SYSTEM.

Handling and Storage Precautions:DUST CAN BE IGNITED BY ELECTROSTATIC
DISCHARGE AND OTHER SOURCES OF IGNITION. DO NOT GENERATE DUST.
GROUND ALL EQUIPMENT. AVOID BREATHING DUST. AVOID PROLONGED OR
REPEATED SKIN AND EYE CONTACT. USE UN DER WELL-VENTILATED
CONDITIONS.
Other Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN USE.

Respiratory Protection:NOT TYPICALLY REQUIRED. IF DUSTY CONDITIONS,
NIOSH APPROVED DUST RESPIRATOR ACCORDING TO OSHA 29 CFR 1910.134.
Ventilation:IF A LOCAL EXHAUST VENTILATION SYSTEM IS USED, A CAPTURE
VELOCITY OF 150-200 FPM IS RECOMMENDED.
Protective Gloves:RUBBER GLOVES.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER .
Work Hygienic Practices:FOR PERSONAL HYGIENE PROTECTION, WASH
THOROUGHLY AFTER HANDLING PRODUCT.
Supplemental Safety and Health

Spec Gravity:1.02
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT TAN TO BROWN FRIABLE POWDER, WITH SLIGHT
AMINE ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS HYDROGEN PEROXIDE, PERMANGANATES &
PERCHLORATES. CONTACT CAN RESULT IN INTENSE HEAT, BOILING, FLAME
DEVELOPMENT, EXPLOSION/TOXIC GAS GENERATION DEPENDING ON AMOUNT OF
SPECIFIC MATERIALS INVOL
Hazardous Decomposition Products:OXIDES OF NITROGEN AND CARBON, SMALL
AMOUNTS OF AROMATIC AND ALIPHATIC HYDROCARBONS.

Waste Disposal Methods:NOT CLASSIFIED AS A RCRA HAZARDOUS WASTE.
INCINERATE OR LANDFILL WASTE ACCORDING TO APPLICABLE ENVIRONMENTAL
REGULATIONS. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS .

Toxicological Information:AMES TEST: NEGATIVE. THIRTEEN WEEK FEEDING
STUDIES IN RATS AND DOGS: DAILY ADMINISTRATION IN THE DIET OF RAT
PRODUCED SOME TOXIC EFFECTS AT LEVELS AS LOW AS 1500 PPM. IN DOGS
NO DISCERNIBLE TOXIC EFFE CTS AT 1500 PPM WERE REPORTED. HIGH
LEVELS OF THIS MATERIAL IN THE DIET CAUSED DEGENERATIVE CHANGES IN
THE LIVER, KIDNEY, ADRENAL MEDULLA AND THYROID OF RATS AND A
DECREASE IN BLOOD PROTHROMBIN CONTEN T IN THE RATS AND DOGS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Transport Information:DOT CLASSIFICATION: NOT REGULATED.

SARA Title III Information:SECTION 313 INGREDIENTS: NONE.
State Regulatory Information: